Shuttle Endeavour grounded by electrical glitch

An electrical glitch forces NASA to postpone the shuttle Endeavour's launch, disappointing President Obama and his family, and Rep. Gabrielle Giffords, wife of commander Mark Kelly.

William Harwood
Bill Harwood has been covering the U.S. space program full-time since 1984, first as Cape Canaveral bureau chief for United Press International and now as a consultant for CBS News. He has covered more than 125 shuttle missions, every interplanetary flight since Voyager 2's flyby of Neptune, and scores of commercial and military launches. Based at the Kennedy Space Center in Florida, Harwood is a devoted amateur astronomer and co-author of "Comm Check: The Final Flight of Shuttle Columbia." You can follow his frequent status updates at the CBS News Space page.
William Harwood
4 min read

KENNEDY SPACE CENTER, Fla.--An electrical glitch with the shuttle Endeavour's hydraulic power system forced NASA managers to scrub today's planned launch on a space station assembly mission, disappointing thousands of spectators and spoiling a visit by President Obama and his family.

The shuttle Endeavour atop pad 39A shortly after a launch scrub was announced. NASA hopes to make another attempt as early as Monday. NASA TV

It also was a disappointment to commander Mark Kelly's wife, U.S. Rep. Gabrielle Giffords (D-Ariz.), who flew to Florida on Wednesday to watch the launch. Giffords has been recovering after being shot in the head during a shooting in January.

"But as we always say in this business, we will not fly this machine until it's ready," said Launch Director Mike Leinbach. "And today, it was not ready to go."

NASA managers do not yet know what it will take to resolve the problem, but they are hopeful a faulty thermostat in a heater circuit is to blame. If so, the shuttle could be ready for another launch attempt as early as Monday at 2:33:56 p.m. EDT.

But if the problem requires a cockpit fuse panel swap out, or installation of a replacement electrical box in the shuttle's aft engine compartment, Endeavour's launch on its 25th and final mission likely will be delayed until May 9 or 10, after the planned May 6 launch of an Atlas rocket carrying a missile early-warning satellite.

Because of a conflict with the planned undocking of a Russian Soyuz spacecraft from the International Space Station at the back end of the shuttle's mission, "we'd probably move to the 9th, maybe even the 10th as our first launch attempt on the other side of Atlas," Moses said.

"We're going to have to go do some homework there and talk to the Russians about exactly the right way to deconflict that," he said. "But we're not going to do too much on that just yet because we think we've still got a shot in front of Atlas."

President Obama and his family toured tornado-damaged Tuscaloosa, Ala., early today and continued on to Florida, landing at the Cape Canaveral Air Force Station as planned shortly after 2 p.m. The first family then boarded a Marine helicopter and flew to the nearby Kennedy Space Center, flying past launch pad 39A for a bird's eye view of Endeavour.

The president and his party toured an orbiter processing hangar, getting a close-up look at the shuttle Atlantis, before moving onto the Launch Control Center where he met with Endeavour's crew, Giffords, and other astronaut family members.

Endeavour commander Mark Kelly and President Barack Obama share a light moment after launch on a space station assembly mission was scrubbed because of an electrical glitch. NASA TV

The president's meeting with Giffords was not recorded and a few minutes later, Obama flew on to Miami.

Endeavour's problem cropped up during fueling when engineers noticed apparent problems with two heater thermostats used by one of the ship's auxiliary power units. Space shuttles are equipped with three APUs to provide the hydraulic muscle needed to move wing flaps, main engine nozzles, landing gear brakes, and other critical systems.

While a shuttle can safely fly with a single APU, NASA flight rules require all three to be operating normally at launch to ensure redundancy. In this case, the concern was the possibility a fuel line could freeze, leaving APU No. 1 just one failure away from a shutdown.

As engineers were assessing the problem, Kelly and his crewmates--pilot Gregory H. Johnson, Michael Fincke, Gregory Chamitoff, Andrew Feustel, and European Space Agency astronaut Roberto Vittori--were preparing for launch, going through final medical checks and donning their pressure suits before heading to the launch pad.

But they knew a potentially serious issue was under discussion and a few minutes after noon, Leinbach called off the countdown and ordered a scrub. The "astrovan" carrying Kelly and his crewmates stopped at the Launch Control Center, paused briefly for a call from Leinbach, then turned around and headed back to crew quarters.

Engineers, meanwhile, drained Endeavour's external tank and held meetings to review data from the ship's hydraulic power system.

Mike Moses, chairman of NASA's Mission Management Team, said it is possible the problem can be explained by a single faulty thermostat. If so, engineers should be able to install a replacement in time for a second launch attempt Monday.

"If there's a thermostat that's failed such that it might have an open circuit in it, not necessarily a short circuit but just an open, that would open up to ground," he said.

"These things are wired together such that all the heaters on the front half of that string share a common ground...So a single failure on one thermostat could still cause this problem."

That's the best-case scenario for NASA.

"The troubleshooting involves taking in a can of (compressed air) and spraying it on the thermostat to see if we can force a lower temperature on the thermostat and have it kick on," Leinbach said. "If that works, we might have just a thermostat that's out of kilter and we can replace that thermostat and we'll be in good shape.

"If it's more than that, then it could be in a box called the LCA. the load control assembly, which is essentially a box full of switches. If there's something wrong in that box and we have to change out that box, that's a much more extensive job. It would take us quite some time to do that."

Engineers hope to climb in the aft compartment tomorrow afternoon to begin troubleshooting. A final decision on how to proceed is expected by midday Sunday at the latest.

NASA's Endeavour on cusp of final flight (photos)

See all photos