CNET también está disponible en español.

Ir a español

Don't show this again

Sci-Tech

SpaceX test-fires modern escape system for Dragon astronauts

The private space-exploration company's passenger capsule roars away from Cape Canaveral Wednesday in a test of its system for boosting a crew to safety in an emergency.


ceu1mhaweaanvna-pnglarge.png
A test vehicle lifts off at Cape Canaveral Wednesday morning. SpaceX via Twitter

Simulating a launch pad emergency, an unmanned SpaceX Dragon capsule was blasted away from Cape Canaveral, Fla., Wednesday, shooting to an altitude of several thousand feet before arcing over for an offshore splashdown. It was a dramatic test of the emergency escape system planned for the private space exploration company's space station crew ships.

SpaceX has a $2.6 billion contract with NASA to develop a piloted version of its Dragon cargo ship to ferry astronauts to and from the International Space Station starting in 2017. Boeing holds a similar contract, valued at $4.2 billion, to build its CST-100 ferry craft.

A key element of the design of both vehicles is the escape system, designed to quickly boost a crew to safety at any point from launch to orbit.

On Wednesday, eight of Dracon's so-called SuperDraco engines mounted in pairs around the base of the eight-ton capsule ignited at 9 a.m. Eastern, reaching a combined thrust of 120,000 pounds and boosting the spacecraft from zero to 100 mph -- straight up -- in one second.

Quickly climbing away from the Cape Canaveral Air Force Station, the SuperDracos burned for just five seconds or so, enough to push the craft away from an impending booster failure in an actual launch attempt. The acceleration subjected an instrumented dummy to about five times the force of Earth's gravity.

After the engines shut down, the capsule continued climbing, coasting to an altitude of about 4,500 feet on an arcing trajectory carrying it just over the coastline from launch complex 40.

At the apex of the arc, the Dragon and its finned trunk section separated as planned. The Dragon capsule immediately flipped around, going through a full 360-degree rotation, before two small drogue parachutes deployed to stabilize the vehicle. A few seconds later, three orange-and-white main parachutes unfurled, gently lowering the spacecraft to the Atlantic Ocean just off shore.

050615trunksep.jpg
The finned trunk section separates from a SpaceX Dragon test vehicle at the apex of its launch abort test trajectory. NASA TV

The finned trunk section separates from a SpaceX Dragon test vehicle at the apex of its launch abort test trajectory. NASA TV SpaceX recovery crews were standing by to pull the capsule onto a waiting barge for the short trip back to port and eventual shipment to a SpaceX facility in Texas for detailed inspections.

While a detailed data review and vehicle inspection will be needed to fully assess the results of Wednesday's test, it appeared to go smoothly and no major problems were apparent. A SpaceX technician reported the velocity at engine cutoff was "slightly below nominal" and the capsule appeared to splash down closer to shore than expected, but overall the test appeared to go well and SpaceX declared it a success.

SpaceX plans to use the same capsule later this year for an in-flight abort test, launching the craft atop a Falcon 9 booster and activating the escape system at the moment of maximum aerodynamic pressure, the most challenging flight regime during ascent. The tests are needed to certify the escape system for use with eventual crewed missions.

NASA's Mercury and Apollo spacecraft featured tower-mounted escape rockets designed to pull a capsule to safety while two-seat Gemini capsules relied on ejection seats. Russian Soyuz ferry craft, which currently carry astronauts and cosmonauts to and from the space station, also are equipped with a rocket-powered escape system attached to the front of the spacecraft.

NASA's space shuttle was equipped with ejection seats for the first four test flights when only two crew members were on board, but the system was deactivated and removed for "operational" flights. While a rudimentary bailout system was implemented in the wake of the 1986 Challenger disaster, there were no survivable abort options for booster failures in the first two minutes of flight.

But NASA's new crew ships -- the agency's Orion deep space exploration vehicle and the Boeing and SpaceX space station ferry ships -- are being designed from the ground up with escape systems that could pull or push a crew to safety at any point from launch to orbit.

050615padabortsplash.jpg
The Dragon capsule descends to an ocean splashdown. NASA TV

The Dragon capsule descends to an ocean splashdown. NASA TV The powerful SuperDraco engines built into SpaceX's crewed Dragon capsules will serve a dual purpose. SpaceX eventually plans to use them for rocket-powered vertical touchdowns on land at the end of a space station mission. But the same engines also are available for quick use if a major problem develops during launch atop a Falcon 9 rocket.

"We're proud to have a launch escape system in case the Falcon 9 is having a bad day," said former shuttle astronaut Garrett Reisman, director of crew operations for SpaceX. "The Dragon crew can get to safety.

"It's a capability we had on Gemini and Apollo, and we have it on the Soyuz, but we did not enjoy that on the shuttle. We're bringing that back to try and make sure our crews are super safe."

For Wednesday's test flight, the Dragon test article was heavily instrumented with sensors to measure multi-axis acceleration, temperature, sound, pressure and a variety of other factors. An instrumented dummy was on board to measure the forces astronauts would experience in a launch abort.

This story was first published as "SpaceX stages dramatic crew escape system test," on CBS News.com.